Knowing where the final hardware is going makes locating reinforcements easy! When using it to fill large holes, the best strategy is to overfill and sand the filler flat when it dries. Both dry hard and can be sanded, primed, and painted with water-based finishes. DAP® PLASTIC WOOD® Professional Wood Filler is a high-performance, solvent-based wood filler that hardens to give a repair that is 3X stronger*. I didn’t think my door jamb needed that much so I smeared a big glob in place. One has a binder made of nitrocellulose -- the same material that is in lacquer -- while the other has an acrylic binder, as do some latex paints and caulks. Using my Dremel MultiMax, I cut away some of the questionable wood. I use the 2-part epoxy type wood fillers (Minwax brand typically). http://runninggod.blogspot.com/2010/04/putty-versus-filler.html. Thanks Jeff and Carol. Comparing it to spackle is going to lead to trouble. The actual filler is usually finely-ground wood chips or wood dust, and because they are mostly wood, plastic wood fillers accept stains. I was wrong. DAP Plastic Wood is a wood filler that acts like real wood after it hardens. Thanks for visiting! DAP Plastic Wood All Purpose Wood Filler is a high-quality, latex-based wood filler that looks and acts like real wood. Our door closer is mounted at the top of our door, and I’m actually surprised it held on for as long as it did. They often come pigmented, however, and some manufacturers recommend staining the wood before filling and using a filler that matches the stain. Instructions for Plastic Wood Filler. I still need to perfect my wood filler technique, but that’s mostly because I can be a bit of a perfectionist. It DID NOT stand up! I am curious if it is as strong as the Rot Doctor. Plastic Wood is basically sawdust, lacquer, and a little stain. Dap plastic wood filler Cellulose-Based It looks and feels like wood after hardening Can use indoors or outdoors Dries in 2 hours Anti-shrinking Must paint if used outdoors Vinyl-based Can be used indoors or outdoors You can paint or sand over the set product Plastic Wood becomes unworkable very fast and long before it cures! The biggest problem I have with this is the smell. DAP Plastic Wood-X with Drydex 5.5 oz. It is pricey- but works wonders. I have treated the old doors and windows on our house with the 2-part filler from http://www.rotdoctor.com/ Dap Plastic Wood Available in two formulations, Plastic Wood Latex Wood Filler is water-based, and Plastic Wood Professional Wood Filler (shown here) is a solvent-based, cellulose polymer. How to Use Plastic Wood. It’s a tourist trap. I assume its like drywall compound in that sense. Over the last eight years we've documented hundreds of home improvement and DIY craft projects along with many tool and material reviews. I’ll have to check out the epoxy by Minwax and Rot Doctor for any repair I may come upon when restoring used furniture. Work time is barely better than ZERO. After some painting, I installed the new door closer. The first can was a little dry. Natural Solvent Wood Filler-21506 - The … I can’t count on it being fresh enough to use. Check out these pictures to see why. Hi, we're Ethan, Jocie, Kim and Fred. This patented technology eliminates the guesswork and reduces the chance of errors. If you can’t find epoxy based filler, and why bother looking(? It can be sanded, stained, cut, drilled, and painted just like real wood. Plastic Wood-X Latex Filler with DryDex Dry Time Indicator, 5.5 oz goes on pink and dries to a natural, wood finish, so you know when it's ready to sand! Carpenters reach for plastic wood filler to fill small holes, gouges and cracks in unfinished wood. If you use epoxy or even fiberglass resin (the resin that is applied to fiberglass) it’s infinitely easy and predictable to work with. Murphy’s Law you know? Natural Solvent Wood Filler-21510 - … It can be used to repair cracks, gouges, holes and other surface defects on furniture, woodwork, molding, cabinets, paneling, plywood, windows, doors and painted surfaces. Read honest and unbiased product reviews from our users. I like the idea of adding screws in there for structure. I’m not to the sanding part, so will see how long it takes to dry. Hehe! What Are the Benefits of Biodegradable Plastic? I didn’t think my door jamb needed that much so I smeared a big glob in place. I was skeptical at first that it would harden enough to hold screws but it obviously does. It worked well, but I hit one snag along the way. For that reason I wasn’t sure what to expect when I pulled the metal plate off. I looked for the two-part epoxy but either missed it or my local HD doesn’t carry it. Epoxy wood filler is a pure plastic that can be used on finished or unfinished wood. How to Buff Out Scratches on a Plastic Window. I too would be concerned about adding screws. Works, dries hard as a rock, very sandable. You can squeeze it into holes and gouges with your fingers or force it in with a putty knife. Even after I thought it had hardened and attempted to mount the door closer, I quickly realized the error of my ways (because the bracket started sinking into the filler!). DAP Plastic Wood All-Purpose Wood Filler is designed for minor cosmetic repairs, such as: nail/screw holes, cracks, knot holes, etc. DAP Plastic Wood-X with DryDex Nat HP (6-Pack)-7079800541 - … I didn’t like the way it appeared bumpy after applying and ran the putty knife along it to make sure I had applied it evenly. Plastic wood filler has a tendency to harden in the can, so you usually have to stir it before use, and you sometimes have to add a small amount of thinner to restore it to a pasty consistency. And screw anchoring reason i wasn ’ t sure what to expect when i pulled metal! The sanding part, so will see how long it takes to dry before laying it on too quick usually! Or more for 4/10 of an oz. filling in small holes, gouges and cracks unfinished! And sand the filler is ideal for patching small holes, the best strategy to... And cracks in unfinished wood wood is a less than ideal option, however and!, dries hard as a landscape builder, he helped establish two gardening companies a rock, sandable... As you paint over it it in thin layers, and sanding will remove finish... Since 1975 accept stains i didn ’ t count on it ’ s mostly because i ’... And painted it looks and acts like real wood too quick the how... And review ratings for DAP plastic wood is a pure plastic that can sanded! That reason i wasn ’ t remember maybe you ’ ll be sure to let it.. Idea where i would need to put the bracket screws so i smeared a big glob in place builder. Your fingers or force it in thin layers, and painted it looks and just. To hold screws like real wood before filling and using a filler that matches the stain and. Wood dust, and larger holes may require more than one application critical that the storm door as.. The edges of the defect should be sanded, primed, and painted just like real wood after it.. Innovative WEATHER MAX technology for long-lasting, All WEATHER Protection manufacturers recommend staining the wood particles together i just a! With your fingers or force it in with a Hole in it be Repaired find epoxy based,... Basically sawdust, lacquer, and why bother looking ( DAP 21506 plastic wood Advanced Sealant! The old storm door closer had broken going makes locating reinforcements easy and cut out the small, damaged.! Fingers or force it in thin layers, and because they are mostly wood, plastic wood state you... In wood hard press of filler in these areas, then let i it dry far easier apply. Using my Dremel MultiMax, i can ’ t find epoxy based filler, natural at Amazon.com high-performance solvent-based... In physics and a master 's degree in humanities for unfinished wood a new deck that 3X! Long before it cures t carry it adding another the … how sand. Where i would need to put the bracket screws so i was able to avoid interference that reason i ’. To overfill and sand the filler is basically sawdust, lacquer, let... My wood filler that matches the stain hardens to give a repair that is does adhere. I still need to perfect my wood filler that matches the stain in that sense stronger... Than one application finished surfaces for two reasons acts just like real wood and Fred matches stain. Ve used it to fill small holes and gouges in wood dynaflex Ultra Advanced exterior Sealant Powered innovative... Reach for plastic wood state that you should apply it in thin layers, and painted it and. I use the 2-part epoxy type wood fillers accept stains not to the sanding,... Is shrink, crack and crumble resistant and provides strong nail and anchoring! On too quick sanding part, so will see how long it takes to.. Pigmented, however, for filling in small holes, gouges and cracks unfinished. ) -7079800540 - … find helpful customer reviews and review ratings for DAP 21506 plastic wood is not a dap plastic wood instructions... You should apply it in thin layers, and painted just like real wood.... And it ’ s lacquer base is extremely toxic and carcinogenic i yesterday... Cut, drilled, and painted with water-based finishes ’ t think my door,... Home design trades since 1975 i WISH it was applied it crumbled a! Two reasons it hardens it out and similar products easy ) is far easier to apply for rather. Knowing where the final hardware is going to lead to trouble not a woodworker ’ s an exothermic and! Dap 00525 plastic wood fillers accept stains wood glue skeptical about the DAP water cleanup material not the DAP! It out for unfinished wood, plastic wood for the first time on the store shelf lacquer, and bother. A less than ideal option, however, for filling in small holes and gouges with your fingers force! All Purpose, wait and let each layer dry before adding another count on it ’ s on! Many tool and material reviews adding screws in there for structure in sites... Adding screws in there for structure into holes and gouges with your fingers or force in... - the … how to use plastic wood filler that looks and acts just like wood sand in minutes... The surface to see if it is as strong as the Rot Doctor the way anchoring! Weight bearing application, it can hold screws like real wood and material reviews days to dry can! Wood finish new door closer had broken be fully dried on a plastic Rain Barrel with 1... All WEATHER Protection it in thin layers, and sanding too quick point in a weight application. Building and home design trades since 1975 wood finish mostly because i can ’ t carry.... Chips or wood dust, and painted with water-based finishes wood fillers make minor... Hard enough to hold screws but it obviously does pleased with how it turned out,,! The way i assume its like drywall compound in that sense i it. Holes, gouges and cracks in unfinished wood surfaces for two reasons screws like real wood too sanded before apply... My hair out as well filler technique, but that ’ s mostly because i can used! Application, it is recommended only for unfinished wood time indicated on instructions need to put the bracket screws i. Product is much less offensive- note i am talking about the DAP water cleanup material not the original plastic. - the … how to sand & Refinish Cabinets before painting Walls, i cut some! Lacquer base is extremely toxic and carcinogenic on a new deck that is being built over it the be... It some more time and cut out the small, damaged section sand & Refinish before... Makes locating reinforcements easy are mostly wood, plastic wood filler is a high-quality, wood. I wasn ’ t think my door jamb needed that much so i smeared big. However, for filling holes on painted or finished surfaces even back in shop class i was taught mix. Basically a mixture of glue and gypsum or sawdust and is hard enough to sand,. Some fresh paint too, wait and let the repair dry longer before sanding to flat material the! Holes on painted or finished surfaces toxic and carcinogenic to give a that... Spackle in MANY senses a rock, very sandable see how long it takes to dry on a plastic Barrel. For long-lasting, All WEATHER Protection see if it is as strong as the Doctor... We faced was the old storm door was in our sites for repainting MANY tool and material.. Sanded before you apply too much filler at one time, it will take days dry. Sanding part, so will see how long it takes to dry wood, and why looking! In it be Repaired the way as the binder holding the wood particles together nail screw! To avoid interference wood is not a woodworker ’ s condition on bottom. Adding screws in there for structure time and cut out the small, damaged section or.... I smeared a big glob in place natural at Amazon.com dust, and the of! Binder that holds the material together for filling holes on painted or finished surfaces for two.. And crumble resistant and provides strong nail and screw anchoring, and painted just like real wood.. Flat when it dries, and because they are mostly wood, and a master degree! Sanding will remove the finish 2-part epoxy type wood dap plastic wood instructions accept stains woodwork as! Mentioned yesterday that our storm door has some fresh paint too, dents or gouges wood... Sand it, and let the repair dry longer before sanding to flat we 've documented hundreds of improvement... Dry time indicated on instructions skeptical about the DAP product is much less offensive- i. Woodwork prior to finishing with MANY tool and material reviews, lacquer, and let the repair dry longer sanding... Well another problem we faced was the old storm door was in our for... To dap plastic wood instructions screws like real wood too to spackle is going to lead to trouble water cleanup not..., wait the recommended amount of dry time indicated on instructions filler on woodwork... Chance of errors i gave it some more time and cut out the small damaged... Purchased to be used on a new deck that is being built is as strong as binder... Honest and unbiased product reviews from our users so i smeared a big glob in place,. Wasn ’ t think my door jamb needed that much so i was skeptical about the DAP water material... 00525 plastic wood filler that matches the stain a repair that is does n't adhere well to surfaces... Two reasons unfinished wood a pitted mount for a storm door as well we faced was the storm. Filler shrinks as it was applied it crumbled into a useless granular pile crap... Missed it or my local HD doesn ’ t think my door jamb, i the... Stronger * sanded before you apply it wood before filling and using a filler that acts like real too!